Hi everyone,
2001 S60 T5 with 140 odd k on the clocks
Parts replaced,
Both front wheel bearings
Both bottom ball joints
Both driveshafts
Both front drop links
Abs pump and module swapped out for a known good one with matching numbers etc
New battery.
Basically it started as something that was intermittent, after a run once the car was stopped and started back up again it would go away but now it's constant.
After disconecting the battery to clear everything
Ignition on, ABS light stays on.
Set off, STC and engine light come on. ABS SYSTEM SERVICE REQUIRED and STC SYSTEM SERVICE REQUIRED in the display
Will skid and will light up when you boot it
Occaisionally the brake light warning light comes up with the message BRAKE FAILURE SERVICE URGENT
turn the car off, come back to it ignition on ABS/EML lights on, start moving then STC light will come on same messages as above.
Once when the ignition was switched on the speedo hobbled about a bit up to about 20mph for a few seconds before the ABS pump madE a noise and the STC light, brake light and the brake failure message came up (ABS/EML already on)
And once had just driven about 10 miles, then turned the car off, turned it back on set off, lights stayed off.......looked down speedo was reading around 40 but was going quicker than that, ABS/STC lights came on and speedo pinged up to 70 witch I was doing
The last 2 have only happened the once
Checked all ABS sensors, all giving good resistance (970 at the front 1040 at the rear), swapped the front ones around and gave them a clean. Slight scores but nothing I'd class as major. Cleaned rear sensors
ABS rings were brand new with the shafts
Slight drag on the rear o/s brake but they do all work
After changing the ABS pump and module flushed brake fluid with dot 5.1 fluid
Had it scanned by Volvokid for codes and this was what was brought up
They cleared but at the time the problem was still intermittent so could probably be doing with running another scan.
Anybody had anything similar or can point me in another direction?
MOT ran out because I couldn't get them sorted in time and Im waiting for an operation on my wrist so progress has been slow!lol
Hoping you guys have some idea or for the first time in 11 years I'm going to have to throw the towel in and chuck it into a main dealer.....or there's going to be a T5 for spares or repairs soon!
Sorry for the long post but I'm hoping someone has had the same symptoms and know what was causing they're issues
Cheers
Bookmarks