Join Today
Results 1 to 4 of 4
  1. #1
    Junior Member
    This user has no status

    Join Date
    Dec 2017
    Posts
    12
    Thanks
    2
    Thanked 0 Times in 0 Posts

    Hu-803 and A/C controller lamp replacement

    Hi all.

    I'm new to Volvos so I don't know a huge amount about them. I have a few issues with mine but with the help from you guys I'll have a solid working barge in no time.

    I've noticed in the short time of having the car (Y reg) some of the lamps in both the stated head unit and the air con panel.

    I've been all over the Internet with not much luck on how to replace the lamps in both units. I understand that almost everything is coded one way or another. I have read if I pull the head unit out it doesn't need coding if it's the one that came out already?

    Are they fairly straight forward?

    What lamps are they and any precautions before doing so like battery disconnection?

    Sorry for the hundred questions.

    All the best

    Ryan


    Sent from my iPad using Tapatalk

  2. #2
    Senior Member
    The daRk knight
    LeeT5's Avatar
    Join Date
    Oct 2004
    Location
    Kent
    Posts
    4,880
    Thanks
    935
    Thanked 1,248 Times in 954 Posts
    This covers the CCM and headlight switch which I did recently. Bulbs are very expensive and some have coloured caps fitted.

    http://www.vpcuk.org/forums/showthre...l=1#post811609

    #30739358 bulb x 4 GREY for CCM 23.24
    #30739356 bulb x 2 WHITE for CCM 11.62
    #30739357 bulb x 3 BLACK for Headlight switch 17.43
    #30752175 bulb x 4 (can't remember colour) for 4 of the 5 switches with blown bulbs in the lower switch pack below CCM 15.48

    Total 81.56 inc VAT.

    Regards the HU, that's more difficult as you'll need to fully remove and strip it down to access the bulbs. Not for the faint hearted!
    Thankfully, mine didn't need doing.
    Last edited by LeeT5; Thursday 7th December 2017 at 09:12.

    2004 V70R 6spd manual:: Custom JRtuning REMAP @ peak 21psi :: Custom 2.75" exhaust :: TTV SMF + 07 Clutch :: WG 5.0 psi :: Tints :: IPD R gauge Rev.3 :: CFWerks door pod :: Forge CBV + yellow spring :: Windowed stock housing + blue filter :: Powerflex :: Superpro Engine mount :: Brembo Dot 5.1 :: TW FMIC :: Eibach 5mm spacers :: Brembo 330mm drilled discs :: iMiV 'Classic'+ BT :: D2R XENARC 5500k + LED H7 + LED H3 :: VolvoTech CFE OBD-V1 :: See garage for full mod list

  3. #3
    Junior Member
    This user has no status

    Join Date
    Dec 2017
    Posts
    12
    Thanks
    2
    Thanked 0 Times in 0 Posts
    Well thanks for that. I've recently bought the car but been away and only starting to notice the little things which is annoying. It was cheap so can't complain too much.

    I have a spare hu as the last owner said the CD player stopped working. But I'm thinking of getting a grom to fit for iPod and other bits so I could just put the old one back in and see if those lamps work. I don't listen to CDs any ways so not a big loss for me.

    Regarding the climate control removal you have to disconnect the battery first and then reconnect it with keys in position (ignition on) to stop Airbags going off. That's extreme. Is that a precaution or will they actually go off? If so that's insane for Volvo to do something like that.

    Thanks for the reply

    Ryan


    Sent from my iPad using Tapatalk

  4. #4
    Senior Member
    The daRk knight
    LeeT5's Avatar
    Join Date
    Oct 2004
    Location
    Kent
    Posts
    4,880
    Thanks
    935
    Thanked 1,248 Times in 954 Posts
    No. It’s just a precaution!
    There’s the potential for them to deploy, hence the advise and proper instructions on how to do it.
    I did mine without unplugging the CCM.

    2004 V70R 6spd manual:: Custom JRtuning REMAP @ peak 21psi :: Custom 2.75" exhaust :: TTV SMF + 07 Clutch :: WG 5.0 psi :: Tints :: IPD R gauge Rev.3 :: CFWerks door pod :: Forge CBV + yellow spring :: Windowed stock housing + blue filter :: Powerflex :: Superpro Engine mount :: Brembo Dot 5.1 :: TW FMIC :: Eibach 5mm spacers :: Brembo 330mm drilled discs :: iMiV 'Classic'+ BT :: D2R XENARC 5500k + LED H7 + LED H3 :: VolvoTech CFE OBD-V1 :: See garage for full mod list


 

Thread Information

Users Browsing this Thread

There are currently 1 users browsing this thread. (0 members and 1 guests)

Bookmarks

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •  
ipv6 ready